| |
Food Facility Inspection Report |
|
|
Bucks County Department of Health
Health Building, Neshaminy Manor Center
Doylestown, PA 18901
(215) 345-3318
|
Total Violations |
5 |
Date of Inspection |
08/14/2023 |
| Risk Violations Count |
3 |
Inspection Time |
01.1 |
| Arrival Time |
13:00 |
Recommended for License |
N/A |
| Travel Time |
00.1 |
Facility Closure |
NO |
|
Food Facility
BIG HEADS OF HOLLAND |
Address
295 BUCK RD UNIT 18
|
City/State
HOLLAND, PA |
Zip Code
18966 |
Telephone
(215) 672-7618 |
Facility ID #
312004 |
Owner
OBS, INC. |
Purpose of Inspection
Compliance # (1) |
License Type
Permanent |
Risk Category
3 |
|
FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
|
|
IN=in compliance
OUT=not in compliance
N/O=not observed
N/A=not applicable
|
|
COS=corrected on-site during inspection
R=repeat violation
|
|
|
| Compliance Status |
COS |
R |
| Demonstration of Knowledge |
| 1 |
OUT |
Certification by accredited program, compliance with Code, or correct responses |
|
X |
| Employee Health |
| 2 |
IN |
Management awareness; policy present |
|
|
| 3 |
IN |
Proper use of reporting; restriction & exclusion |
|
|
| Good Hygienic Practices |
| 4 |
IN |
Proper eating, tasting, drinking, or tobacco use |
|
|
| 5 |
IN |
No discharge from eyes, nose, and mouth |
|
|
| Preventing Contamination by Hazards |
| 6 |
IN |
Hands clean & properly washed |
|
|
| 7 |
IN |
No bare hand contact with RTE foods or approved alternate method properly followed |
|
|
| 8 |
OUT |
Adequate handwashing facilities supplied & accessible |
|
X |
| Approved Source |
| 9 |
IN |
Food obtained from approved source |
|
|
| 10 |
N/O |
Food received at proper temperature |
|
|
| 11 |
IN |
Food in good condition, safe, & unadulterated |
|
|
| 12 |
N/A |
Required records available: shellstock tags, parasite destruction |
|
|
| Protection from Contamination |
| 13 |
IN |
Food separated & protected |
|
|
| 14 |
OUT |
Food-contact surfaces: cleaned & sanitized |
|
X |
| 15 |
IN |
Proper disposition of returned, previously served, reconditioned, & unsafe food |
|
|
|
|
| Compliance Status |
COS |
R |
| Potentially Hazardous Food Time/Temperature |
| 16 |
N/O |
Proper cooking time & temperature |
|
|
| 17 |
N/O |
Proper reheating procedures for hot holding |
|
|
| 18 |
N/O |
Proper cooling time & temperature |
|
|
| 19 |
N/O |
Proper hot holding temperature |
|
|
| 20 |
IN |
Proper cold holding temperature |
|
|
| 21 |
N/O |
Proper date marking & disposition |
|
|
| 22 |
N/O |
Time as a public health control; procedures & record |
|
|
| Consumer Advisory |
| 23 |
N/A |
Consumer advisory provided for raw or undercooked foods |
|
|
| Highly Susceptible Populations |
| 24 |
IN |
Pasteurized foods used; prohibited foods not offered |
|
|
| Chemical |
| 25 |
N/A |
Food additives: approved & properly used |
|
|
| 26 |
IN |
Toxic substances properly identified, stored & used |
|
|
| Conformance with Approved Procedure |
| 27 |
N/A |
Compliance with variance, specialized process, & HACCP plan |
|
|
Risk factors are improper practices or procedures identified as the most
prevalent contributing factors of foodborne illness or injury. Public Health
Interventions are control measures to prevent foodborne illness or injury. * - Critical Item Requiring Immediate Action
|
|
| GOOD RETAIL PRACTICES |
Good Retail Practices are preventative measures to control the addition of pathogens,
chemicals, and physical objects into foods.
|
|
| Compliance Status |
COS |
R |
| Safe Food and Water |
| 28 |
IN |
Pasteurized eggs used where required |
|
|
| 29 |
IN |
Water & ice from approved source |
|
|
| 30 |
IN |
Variance obtained for specialized processing methods |
|
|
| Food Temperature Control |
| 31 |
IN |
Proper cooling methods used; adequate equipment for temperature control |
|
|
| 32 |
IN |
Plant food properly cooked for hot holding |
|
|
| 33 |
IN |
Approved thawing methods used |
|
|
| 34 |
IN |
Thermometer provided & accurate |
|
|
| 35 |
IN |
Food properly labeled; original container |
|
|
| Prevention of Food Contamination |
| 36 |
OUT |
Insects, rodents & animals not present; no unauthorized persons |
|
X |
| 37 |
IN |
Contamination prevented during food preparation, storage & display |
|
|
| 38 |
IN |
Personal cleanliness |
|
|
| 39 |
IN |
Wiping cloths: properly used & stored |
|
|
| 40 |
IN |
Washing fruit & vegetables |
|
|
|
|
| Compliance Status |
COS |
R |
| Proper Use of Utensils |
| 41 |
IN |
In-use utensils: properly stored |
X |
X |
| 42 |
IN |
Utensils, equipment & linens: properly stored, dried & handled |
|
|
| 43 |
IN |
Single-use & single-service articles: properly stored & used |
|
|
| 44 |
IN |
Gloves used properly |
|
|
| Utensils, Equipment and Vending |
| 45 |
IN |
Food & non-food contact surfaces cleanable, properly designed, constructed, & used |
|
|
| 46 |
IN |
Warewashing facilities: installed, maintained, & used; test strips |
|
|
| 47 |
IN |
Non-food contact surfaces clean |
|
|
| Physical Facilities |
| 48 |
IN |
Hot & cold water available; adequate pressure |
|
|
| 49 |
IN |
Plumbing installed; proper backflow devices |
|
|
| 50 |
IN |
Sewage & waste water properly disposed |
|
|
| 51 |
IN |
Toilet facilities: properly constructed, supplied, & cleaned |
|
|
| 52 |
IN |
Garbage & refuse properly disposed; facilities maintained |
|
|
| 53 |
IN |
Physical facilities installed, maintained, & clean |
|
|
| 54 |
IN |
Adequate ventilation & lighting; designated areas used |
|
|
|
|
|
|
|
|
| |
Food Facility Inspection Report |
|
|
Bucks County Department of Health
Health Building, Neshaminy Manor Center
Doylestown, PA 18901
(215) 345-3318
|
Date of Inspection |
08/14/2023 |
| Arrival Time |
13:00 |
| Recommended for License |
N/A |
| Facility Closure |
NO |
|
Facility
Big Heads of Holland |
Address
295 BUCK RD UNIT 18
|
City/State
HOLLAND, PA |
Zip Code
18966 |
Telephone
(215) 672-7618 |
Facility ID #
312004 |
Owner
OBS, INC. |
Purpose of Inspection
Compliance # (1) |
License Type
Permanent |
Risk Category
3 |
|
|
TEMPERATURE OBSERVATIONS
|
| Item/Location |
Temp |
Item/Location |
Temp |
Item/Location |
Temp |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| OBSERVATIONS AND CORRECTIVE ACTIONS |
Item
Number |
Violations cited in this report must be corrected within the time frames below.
|
|
*1
|
*There is no food safety manager certified by this Department (CFSM) on duty as required. A CFSM must be on duty at all times the facility is open and/or food is being prepared. A completed application(SA-71)for CFSM, or proof of enrollment in an approved food safety class must be submitted to the Department within 5 business days. Repeat Violation. To be Corrected By: 08/21/2023
|
|
*8
|
*Soap was lacking at the and bar hand sink. Soap must be provided.
(b) Availability of handwashing cleanser. Each handwashing sink or group of two adjacent sinks shall be provided with a supply of hand cleaning liquid, powder or bar soap. Repeat Violation. To be Corrected By: 08/14/2023
|
|
*14
|
*-The hot water did not reach a minimum of 120 degrees F during the wash and rinse cycles of the bar glass washer. The dish machine must be repaired or the hot water heater must be adjusted, to provide hot water at a minimum of 120 degrees F.
-The sanitizer was tested at approximately 25 ppm after several cycles. Sanitizer must be available at 50-100 ppm.
The facility must manually wash, rinse, and sanitize all utensils until the unit is repaired, and permission for use is granted by the Department. Submit a work order for repair to the Department. The facility may be required to replace the dish machine, due to repeated violations. Repeat Violation.
|
|
*14
|
*Debris on the splash guard inside the ice machine near the beer walk-in cooler.
Clean and sanitize. Clean as often as necessary to maintain. Repeat Violation. To be Corrected By: 08/16/2023
|
|
36
|
*Drain fly-like insects observed around the mop sink. The facility must have a professional pest control operator treat for the target pest. Submit an invoice/receipt for treatment to the Department within 5 business days. Repeat Violation. To be Corrected By: 08/21/2023
|
|
41
|
The ice scoops were stored inside the ice machine between uses. The ice scoops are designed for storage inside the machine, in a designated holding place.
During pauses in food preparation or dispensing, food preparation and dispensing utensils may be stored on a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the table or equipment are cleaned and sanitized at a frequency specified in §§ 712 and 731 (relating to frequency of cleaning equipment food-contact surfaces and utensils; and sanitization: requirement, frequency and methods).
(c) Storage in running water. During pauses in food preparation or dispensing, food preparation and dispensing utensils may be stored in running water of sufficient velocity to flush particulates to the drain, if used with moist food such as ice cream or mashed potatoes.
(d) Storage in clean, protected locations. During pauses in food preparation or dispensing, food preparation and dispensing utensils may be stored in a clean, protected location if the utensils, such as scoops, are used only with a food that is not potentially hazardous.
(e) Storage in a container of water. During pauses in food preparation or dispensing, food preparation and dispensing utensils may be stored in a container of water if the water is maintained at a temperature of at least 58°C (135°F) and the container is cleaned at frequency specified in § 712(d)(7). Corrected On-Site. Repeat Violation.
|
|
|
|
|
|
|
|
General Remarks
|
|
BCDH will conduct a compliance inspection on or before 08/21/23. The facility may be charged a regulatory fee for each compliance inspection.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|